Skip to content

Safety Information

This section contains important safety instructions for the safe operation, towing, and use of your BreathTrailer.

⚠️ Failure to follow these instructions may result in personal injury, equipment damage, or loss of warranty.

General Safety Guidelines

  • Always read and understand this manual before using the trailer.
  • Only operate the trailer and its systems as described in this manual.
  • Do not modify or alter any installed system unless approved by an authorised technician.
  • Keep this manual accessible at all times.

Towing & Road Safety

  • Always ensure the trailer coupling is correctly locked onto a 50mm tow ball.
  • Safety chains must be attached and crossed underneath the coupling.
  • Ensure the trailer handbrake is fully released before towing.
  • Verify that the electrical plug is connected and functioning correctly.
  • Never exceed the trailer’s rated towing or load limits.
  • Drive at safe speeds suitable for road and weather conditions.

⚠️ Never tow the trailer with the handbrake engaged.

Electrical Safety

  • 12V and 240V systems operate differently and must be used correctly.
  • Always check the power selector switch position before using 240V outlets.
  • Do not use damaged cables, plugs, or electrical equipment.
  • Do not overload the inverter.
  • High-power appliances such as kettles, heaters, air fryers, and hair dryers must not be used with the inverter.

⚠️ Improper electrical use may cause system shutdown or damage.

Battery Safety

  • Batteries must not be exposed to excessive heat, water, or physical damage.
  • Ensure adequate ventilation around battery systems.
  • Do not short-circuit battery terminals.
  • Turn off unused electrical systems to prevent excessive battery discharge.

Gas Safety

  • Only use approved LPG gas cylinders with the correct Australian-standard connection.
  • Ensure gas connections are secure before use.
  • Never operate gas appliances in enclosed or poorly ventilated spaces.
  • Turn off gas supply when the hot water system is not in use.

⚠️ Gas misuse can result in serious injury or fire.

Water System Safety

  • Ensure the water pump is switched ON only when water is available in the system.
  • Do not operate the pump dry for extended periods.
  • Drain water systems when required, especially before long-term storage.

Awning & Outdoor Equipment Safety

  • Do not deploy awnings in strong winds or extreme weather.
  • Ensure the vehicle is stationary with the handbrake applied before setup.
  • Always pack away awnings and tents immediately if weather conditions worsen.

Maintenance & Inspection

  • Regularly inspect the coupling, safety chains, electrical connections, and gas fittings.
  • Address any damage or faults before using the trailer.
  • Only use authorised parts and service providers.

Emergency Situations

  • In the event of electrical, gas, or water system failure, switch off the affected system immediately.
  • If a fire risk is suspected, disconnect power and gas supplies if safe to do so.
  • Seek professional assistance before resuming use.

By following these safety guidelines, you help ensure safe operation, system reliability, and long-term performance of your BreathTrailer.